Schedule A Quote

Phone: 305-356-1044
Email US

Cast Iron Under Slab
Vertical Condo Drains
6 Installation Steps
About Us

Cutler Bay Trenchless Pipe Lining Company Restores Underground Pipes For 50 Years, Without Excavation!

If your home was built before 1972 in Cutler Bay, then your underground drains are certainly made of cast iron. If you have been experiencing repeated backups, then you’re going through the same process as all of your other neighbors. Cast iron pipes have a limited life span of 50 years and during that period the bottom of the pipe corrodes the fastest because that’s where the water rests. After. Eventually, the bottom of the pipe becomes so thin that it eventually cracks, and as the crack widens, the serrated edges of the cracks catch the debris trying to flow down the pipe, which causes repeated backups. When your plumber uses a video camera to see what’s causing the backups, they will tell you that the pipes have to be replaced.

 

Rusted cast-iron drains before trenchless sewer repair restoration

AVOID Excavation through the slab to replace cast iron drains. Trenchless sewer drain replacement lasts 50+ years

This 50-year warranty pipe lining stops backups permanently

These days however instead of replacing the pipe, which takes about two months and costs about $50,000 for a 2000 square foot house, we can use our pipe lining technologies to restore the pipe for a minimum of 50 years. All the work is done from the outside of the house, and it typically takes about four days, during which all the plumbing can be used all the time, except for once a day for about 4 hours in the middle of the day. Our pipe lining process has a 50-year transferable warranty and costs about 40% as much as pipe replacement.

We do our estimates in Pinecrest every Tuesday and Wednesday, it takes about 15 minutes at the most to take measurements and we give you the quote immediately.

Here is a list of names, cities, and phone numbers of hundreds of our customers that you can call!

Here Are The 2 Common Technologies Used As Of 2020 To Rehabilitate/Repair Underground Cast Iron Drains Without Excavation

Benefits Of Trenchless Pipe Lining

  • No digging through your floors
  • Much less expensive – pipe relining costs about 50% less than excavation
  • Save your tile, wood, or marble – it’s usually impossible to find matching floor surfaces that were installed decades ago
  • Stay in your home, not a hotel – pipe relining is done from outside, so you can stay in your residence
  • Speed – pipe lining takes 1 day, not months as for pipe replacement by excavation
  • The plumbing can be used during installation except for 3-4 hours a day

How Is It Installed, And What’s The Cost In Miami-Dade County?

From outside your property, we open the pipe, clean out the rust, scale, and roots, and then install a new “pipe liner” or sleeve which has been saturated with a self-hardening epoxy resin. The liner contains a balloon which is inflated for 3 hours while the resin becomes rock-hard. Then the balloon is removed and a video inspection is performed to ensure correct installation. The pipe is put back into use immediately. A 2,000 square foot house would cost about $17,000 to re-line. Learn more pipe lining installation details here.

Video Of Re-Lined Cast Iron Drain Pipe (Containing 2 x 45-Degree Bends)

How Strong Is The Pipe Lining?

The pipe liner is a fabric tube made of polyester which is then “wet out” with a 2-part epoxy resin which is mixed together in a certain proportion. In about 30 minutes resin heats up by itself to 180 degrees Fahrenheit due to an exothermic chemical reaction and becomes rock hard.

The resulting new inner pipe liner is so strong that it is a stand-alone pipe, not needing the old exterior pipe for structural integrity. The liner is designed to go under load-bearing footers, roads, driveways, etc.

Here’s A Video of Hugo Forster In Miami Jumping On A Pipe Liner, Beating It With A Hammer!

Video of Vertical Stack Pipe Re-Lining On Top Of A High Rise In Ft. Lauderdale

Google+
Contact Us

    I would like to:

    What Type of Property Need Pipe Lining Service :

    Your Name:

    Your Email:

    Address:

    City, State, Zip:

    Phone:

    Questions/Comments:

    FEATURED PROJECTS
    Triton Towers, Miami Beach
    Historic Guarantee Building
    West Palm
    Patrick Air Force Base
    Melbourne
    The Prince Condominiums
    Marco Island, FL
    Harbor House
    Naples, FL
    SERVING THE FOLLOWING AREAS:
    Tampa
    St. Petersburg
    Sarasota
    Venice
    Cape Coral
    Naples
    Miami
    Fort Lauderdale
    West Palm Beach
    Port St Lucie
    Delray Beach
    Boca Raton
    Pompano Beach
    Hollywood
    Coral Gables
    Fort Myers
    Port Charlotte
    Orlando
    Clearwater
    Longboat Key